Generator Electronics

Fix Number

FIX18992714

Manufacturer Part Number

GS-0748

This replacement part is specially designed for Porter Cable, DeWALT and DeVilbiss portable generators. The capacitor is a two-terminal electrical device used to store electrical energy in the form of an electric field. It provides leading current in AC circuits. In a DC circuit, the capacitor once charged with the applied voltage acts as an open switch. This is an identical replacement for a missing or a faulty component that was installed on a new unit. Please make sure to refer to the appropriate diagram of your model for the exact location and the correct repair procedure. Keep in mind this high-quality capacitor is sold individually.

Fix Number

FIX11870891

Manufacturer Part Number

0034843.01

This diode in your generator is an electrical one-way valve, converting alternating current (AC) into direct current (DC) for a stable and reliable power output. It is usually positioned near the stator and endbell. If the diode malfunctions or gets damaged, you might notice issues like inconsistent power output or voltage fluctuations when using electrical devices. A simple multimeter test can determine its functionality, where a proper diode should allow current in one direction and block it in the other. If it fails the test or shows signs of damage, replacement is recommended. For replacement, remove the rear power cover. Carefully detach the old diodes and cut each wire close to where it was soldered to the diodes. Strip about a quarter-inch of insulation from both wire ends and solder them to new diodes. Reattach the new diodes to the power cover. While performing the replacement, you can also add grease to the roller bearing and clean the area where the brushes make contact on the armature. Finally, replace the old carbon brushes with new ones, ensure all wires are properly connected, and reinstall the power cover onto the generator body. It is important to note that this OEM replacement part is sold separately from the carbon brushes, the capacitor, and any accompanying hardware.

Fix Number

FIX11870945

Manufacturer Part Number

0048677SRV

It is a genuine item that is supplied directly from the original equipment manufacturer for use with Powermate generators. This is an identical replacement for a faulty, a damaged or a missing bridge diode that was installed on a new unit. Note, this high-quality component is sold individually. A screwdriver will be needed to perform this repair. Make sure to refer to the owner's manual and the appropriate diagrams for your model to ensure the correct replacement procedure.

Fix Number

FIX11871798

Manufacturer Part Number

0063065SRV

Fix Number

FIX11871797

Manufacturer Part Number

0063064SRV

Fix Number

FIX10035633

Manufacturer Part Number

95672

Fix Number

FIX11871119

Manufacturer Part Number

0051251SRV

This replacement part is specially designed for Powermate generators. The capacitor is a two-terminal electrical device used to store electrical energy in the form of an electric field. It provides leading current in AC circuits. In a DC circuit, the capacitor once charged with the applied voltage acts as an open switch. This is an identical replacement for a missing or a faulty component that was installed on a new unit. Please make sure to refer to the appropriate diagram of your model for the correct location and application of this capacitor. Keep in mind this high-quality item is sold individually.

Fix Number

FIX11871688

Manufacturer Part Number

0062584SRV

Fix Number

FIX9940413

Manufacturer Part Number

312700GS

Fix Number

FIX9941400

Manufacturer Part Number

31710-ZS9-A02